The maintenance of the Mahindra tractor is discussed in detail.
 |
| Mahindra Tractor |
Maintenance of Mahindra Tractor
Warranty Guidelines:
01. Warranty of any part of the engine, gearbox, hydraulic, and transmission department of Senalika Tractor is 24 months or 2000 hours. (Based on whichever comes first from the date of purchase)
02. If any problem is caused due to driving by an incompetent driver, it will not be covered by warranty.
03. If the tractor is damaged due to an accident, the damaged parts will not be covered under warranty.
04. According to all other tractors, only Myco Villa will be responsible for the warranty of the fuel pulp of Senalika tractors. ACI will not carry any type of Savar.
05. Electrical parts- ball, wiring, a switch will be covered under warranty. Before purchasing a tractor, the buyer is advised to make sure that all these parts are in good condition.
06. Engine Oil & Oil Filter, Diesel Filter, Oil Seal, Rubber Ring, Gasket, Silver Head Gasket, Hose Pipe, Belt & Nut, Lining, Brake Lining, Plastic Parts, Chain & Pin, Front & Rear Wheels, Bearings, Etc. Parts will not fall under warranty.
07. Battery, tire, tire tube, self-starter, and alternator are outside warranty.
08. No warranty will be given for machining and welding work.
09. If any defect occurs in the tractor using low-quality engine oil and diesel, it will not be covered by the warranty.
10. ACI's decision regarding the warranty will be taken unanimously.
Special Guide to Mahindra Tractors
Engine oil:
Engine oil must first be changed every 50 hours. Then change every 250 hours.
Engine oil grade:
Engine oil grade 20w40 (Senalika engine oil) should be used.
Fuel system
Filter:
Primary and secondary fuel filters need to be replaced every 50 hours and then every 250 hours.
Water Separator:
Every day the frozen water should be discarded.
Feed / AC Pump Filter:
Must be cleaned every hour.
Fuel Cock Filter (Fuel Tank Filter) It should be cleaned every 250 hours.
Cooling system:
Radiator's water must be seen every day. If water is low, it should be filled with clean water from rivers, ponds, or rain. Never be filled with tubewell water or mineral water. Radiator flash (completely clean) every 1500 hours. Have to.
Air cleaner:
Dry-type (RX model):
The outer filter should be cleaned by air every 50 hours and the outer filter should be changed every 650 hours.
Wet type (DI model):
Oil must first be changed in 50 hours. Then change every 250 hours.
Hydraulic system:
Hydraulic filter:
First, you have to change in 50 hours. Then change every 250 hours.
Hydraulic Stainer:
Clean every 250 hours and change every 750 hours.
Gearbox:
Gear oil needs to be changed every 1000 hours. Gear oil grade SAE80.
Tractor Maintenance: